刘赛赛,马旭,王宇唯,等. 水稻田间育秧水肥药变量喷灌装置设计与试验[J]. 农业工程学报,2024,40(13):1-14. DOI: 10.11975/j.issn.1002-6819.202402108
    引用本文: 刘赛赛,马旭,王宇唯,等. 水稻田间育秧水肥药变量喷灌装置设计与试验[J]. 农业工程学报,2024,40(13):1-14. DOI: 10.11975/j.issn.1002-6819.202402108
    LIU Saisai, MA Xu, WANG Yuwei, et al. Design and experiment of a variable rate spraying irrigation equipment of water-fertilizer-pesticide for rice seedlings in paddy field[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2024, 40(13): 1-14. DOI: 10.11975/j.issn.1002-6819.202402108
    Citation: LIU Saisai, MA Xu, WANG Yuwei, et al. Design and experiment of a variable rate spraying irrigation equipment of water-fertilizer-pesticide for rice seedlings in paddy field[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2024, 40(13): 1-14. DOI: 10.11975/j.issn.1002-6819.202402108

    水稻田间育秧水肥药变量喷灌装置设计与试验

    Design and experiment of a variable rate spraying irrigation equipment of water-fertilizer-pesticide for rice seedlings in paddy field

    • 摘要: 为解决南方水稻工厂化田间育秧水肥药人工管理作业中存在的灌溉均匀性差、化肥和农药浪费以及劳动强度大等问题,该研究设计了一种水稻田间育秧水肥药变量喷灌装置,阐述了水肥药变量喷灌装置总体结构和工作原理,进行了关键部件设计与试验;以可编程逻辑控制器(programmable logic controller,PLC)为控制核心,构建了注肥量在线调控及整机变量喷灌控制系统。采用Box-Behnken试验设计方法,对装置喷灌均匀性与主要影响因素进行试验研究,应用单目标优化方法对喷灌关键参数进行优化,并通过验证试验,得到最优参数组合为:干管入口水压0.20 MPa、球阀开度90°、喷头喷角80°,此时装置的喷灌均匀性为92.69%;构建了氯化钾肥液质量浓度与电导率(electrical conductance,EC)值的线性模型,开展了装置变量灌溉施肥性能试验,3种喷灌等级下各作业区的肥液EC值分别为1.65、1.66和1.68 mS/cm,平均喷灌强度分别为900.85、1092.041263.67 mm/h,施肥均匀系数分别为85.21%、87.86%和91.62%。采用水肥药变量喷灌装置开展水稻育秧田间管理试验,华航51常规稻和广8优165杂交稻的秧苗长势均匀度均高于95%,成毯性良好,各项素质指标满足机插作业要求。所设计的水肥药变量喷灌装置能够满足水稻田间育秧水肥药变量喷灌作业要求,对提高水稻工厂化田间育秧机械化水平、保证秧苗质量具有实际应用价值。

       

      Abstract: Machine transplanting has been the primary technique of rice seedlings in cultivation in recent years. Among them, factory-scale greenhouses have been commonly used for seedling cultivation in northern China. By contrast, paddy-field seedling can be widely used to cultivate rice transplanting in southern China, according to climate, environment, and production costs. However, manual seedlings are limited to the high labor intensity and the waste of chemical fertilizers and pesticides. It is very necessary to improve the irrigation uniformity in the management of water-fertilizer-pesticide in rice paddy fields. In this study, a variable-rate spraying device was designed for water-fertilizer-pesticide irrigation in rice seedlings. A systematic analysis was performed on the large variable-rate sprinkler and the supporting equipment of fertilizer injection at a high-quality level. The overall structure and working principle were clarified for the variable-rate spraying irrigation device of water-fertilizer-pesticide for seedlings; FLUENT software was used to conduct numerical simulation on the sprinkler irrigation variable-diameter pipeline, in order to determine the optimal structural layout of variable-diameter pipeline; The flow rate of sprinkler and the inlet water of main pipe were then determined after experiments. The curved surface model was established for the pressure and electric ball valve opening; A fertilizer injection and dosing mechanism were designed using proportional integral derivative (PID) self-tuning. The real-time equal-proportion fertilizer or medicine injection was realized after optimization. The online control system of fertilizer injection and variable-rate spraying was constructed with the mitsubishi programmable logic controller (PLC) as the control core. The Box-Behnken experiment was adopted to explore the uniform performance and influencing factors of the device for spraying irrigation. The single objective optimization was applied to determine the key parameters of the device for sprinkler irrigation. The optimal combination of parameters was obtained as follows: The inlet water pressure of the main pipe was 0.20 MPa, the electric ball valve opening was 90°, and the nozzle spraying angle was 80°. Christiansen uniformity of the device was 92.69% in this case; There was a linear model between the mass concentration and electrical conductance (EC) value of the potassium chloride fertilizer solution. The variable-rate irrigation and fertilization experiments were conducted on the device. The EC values of the water-fertilizer mixture were 1.65, 1.66, and 1.68 mS/cm, respectively, in the three spraying irrigation levels. The average values of sprinkler intensity were 900.85, 1092.04, and 1263.67 mm/h, respectively. The fertilization uniformity coefficients were 85.21%, 87.86%, and 91.62%, respectively. There was a small fluctuation of EC values for the water-fertilizer mixtures under the three sprinkler irrigation levels of Ⅰ, Ⅱ, and Ⅲ. The average irrigation intensity of sprinklers varied greatly, where the coefficient of uniformity of fertilizer application was higher than 85%. The field test of rice seedlings was carried out using the variable-rate spraying device of water-fertilizer-pesticide for seedlings. The rice varieties were selected as Huahang51 conventional rice and Guang8You165 hybrid rice. The uniformity of seedling growth was higher than 95% at 13, 21, and 28 d after seeding. There were excellent quality indexes and rooting performance of the seedlings. The various quality indicators of rice seedlings fully met the requirements of machine transplanting. The experiment results showed that the variable-rate spraying device of water-fertilizer-pesticide system shared an accurate, real-time, and proportional fertilizer injection, irrigation, and pesticide spraying in rice paddy fields. The finding can provide a practical application to improve the mechanization level of rice paddy field seedlings for the high-quality of seedlings.

       

    /

    返回文章
    返回