宋学锋, 戴飞, 史瑞杰, 王锋, 张锋伟, 赵武云. 基于非球形颗粒模型的胡麻脱粒物振动分选仿真与试验[J]. 农业工程学报, 2022, 38(10): 39-46. DOI: 10.11975/j.issn.1002-6819.2022.10.005
    引用本文: 宋学锋, 戴飞, 史瑞杰, 王锋, 张锋伟, 赵武云. 基于非球形颗粒模型的胡麻脱粒物振动分选仿真与试验[J]. 农业工程学报, 2022, 38(10): 39-46. DOI: 10.11975/j.issn.1002-6819.2022.10.005
    Song Xuefeng, Dai Fei, Shi Ruijie, Wang Feng, Zhang Fengwei, Zhao Wuyun. Simulation and experiment of the vibration separation of flax threshing material using non-spherical particles model[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2022, 38(10): 39-46. DOI: 10.11975/j.issn.1002-6819.2022.10.005
    Citation: Song Xuefeng, Dai Fei, Shi Ruijie, Wang Feng, Zhang Fengwei, Zhao Wuyun. Simulation and experiment of the vibration separation of flax threshing material using non-spherical particles model[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2022, 38(10): 39-46. DOI: 10.11975/j.issn.1002-6819.2022.10.005

    基于非球形颗粒模型的胡麻脱粒物振动分选仿真与试验

    Simulation and experiment of the vibration separation of flax threshing material using non-spherical particles model

    • 摘要: 为提高仿真中胡麻脱粒物形状真实程度,减小仿真建模误差,该研究基于开源离散元法框架,采用超二次曲面单元法建立了胡麻脱粒物不同组分的非球形颗粒,对多级振动筛分过程进行了仿真与试验研究。研究中分析了一级筛、二级筛的筛面物料分布情况、不同物料的透筛率及含杂率,并开展了试验验证。仿真结果表明:超二次曲面法建立的非球形颗粒能很好地模拟真实物料的物理特性;一级筛中籽粒、短茎秆透筛率分别为99.08%、66.49%,蒴果可被分选;二级筛中籽粒、短茎秆透筛率分别为96.38%、4.79%,短茎秆可被分选。被分选的物料在激振作用下可在对应的筛面发生利于筛分的迁移。不同物料的含杂率统计结果分别为籽粒4.87%,短茎秆21.95%,蒴果3.38%。验证试验结果表明,胡麻脱粒物不同组分的透筛率、含杂率仿真与试验值的相对偏差均小于10%。研究结果证明超二次曲面法建立的非球形颗粒模型适用于振动分选作业。

       

      Abstract: Abstract: Flax is one of the five major oil crops in China. However, the local planting areas are mostly mountainous and hilly landform, and the harvesting process is excessively dependent on manual operation. Due to the problems of high labor intensity and low rate of mechanized equipment for harvesting operation, the development process of flax industrialization in China is seriously restricted. At present, the flax harvest process is still dominated by segmented harvest, and the threshing material formed after flax harvest needs to be separated and cleaned to remove the impurities in the grain. According to different principles, grain separated process can be divided into vibration screening and pneumatic sorting. Discrete element modeling technology is an auxiliary research method widely used in vibration screening research, which can establish various material shapes in agricultural production. However, the existing research methods use the multi-spherical aggregation method to fit the shape of grain and stalks, which is different from the real material in structure. On this basis, in order to improve the shape reality of flax threshing material and reduce the simulation modeling error, based on the open source discrete element method framework, the non-spherical particles of different components of flax threshing material were established by using the super-quadric surface element method, and the multi-stage vibration screening process was simulated and experimentally studied. In this study, the distribution of materials on the screen surface of the first screen and the second screen, the percentage passing and impurity content of different materials were analyzed, and the experimental verification was carried out. Different shapes of flax threshing could be constructed by changing the parameters of the super-quadric control equation. According to the volume fraction of different components of flax threshing, 3 148 grains, 1 728 stems and 124 fruits were generated in the simulation, respectively. In order to facilitated the analysis of simulation data, the primary screen and the secondary screen were divided into three different data statistical areas. The vibrating screening process was mainly analyzed from the material distribution on the screen surface, the screening rate of different materials and the impurity content. The results showed that the non-spherical particles of super-quadric surface could well simulate the physical properties of real materials; The percentage passing of seed and short stalks in the first screen was 99.08% and 66.49%, respectively, and the whole fruit could be sorted; In the second screen, the percentage passing of seed and short stalks were 96.38% and 4.79%, respectively, and the short stalks could be sorted. The sorted material could migrate on the corresponding screen surface under the excitation, which was conducive to screening. The impurity contents of different materials were counted, including 4.87% for seed, 21.95% for short stalks and 3.38% for whole fruit. Then the simulation process was experimented and verified. The composition and quantity of flax thresher in the test were consistent with the simulation, and the different components were mixed evenly before the experiment. In addition, the equipment must be subject to idle commissioning before the threshing material were dumped into the first screen. After the experiment, counting the quantity of different materials from the bottom collecting tank to the first screen. The experiment results showed that the relative data deviations of percentage passing and impurity content of different components of flax threshing materials were less than 10%. Although the modeling method used in the study has good shape fitting degree for non-spherical particles, it still had some limitations, which were discussed in this study. The results showed that the non-spherical particles established by the super-quadric surface method could be applied to the simulation of non-spherical materials involved in different agricultural production process.

       

    /

    返回文章
    返回