曾山, 魏斯龙, 廖明铭, 曾力, 陈海波. 水稻直播机气流式施肥监测系统设计与试验[J]. 农业工程学报, 2022, 38(17): 22-30. DOI: 10.11975/j.issn.1002-6819.2022.17.003
    引用本文: 曾山, 魏斯龙, 廖明铭, 曾力, 陈海波. 水稻直播机气流式施肥监测系统设计与试验[J]. 农业工程学报, 2022, 38(17): 22-30. DOI: 10.11975/j.issn.1002-6819.2022.17.003
    Zeng Shan, Wei Silong, Liao Mingming, Zeng Li, Chen Haibo. Design and experiments of the airflow type fertilizer application monitoring system for rice direct seeders[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2022, 38(17): 22-30. DOI: 10.11975/j.issn.1002-6819.2022.17.003
    Citation: Zeng Shan, Wei Silong, Liao Mingming, Zeng Li, Chen Haibo. Design and experiments of the airflow type fertilizer application monitoring system for rice direct seeders[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2022, 38(17): 22-30. DOI: 10.11975/j.issn.1002-6819.2022.17.003

    水稻直播机气流式施肥监测系统设计与试验

    Design and experiments of the airflow type fertilizer application monitoring system for rice direct seeders

    • 摘要: 针对水稻直播机施肥装置施肥过程中易堵塞及无法及时报警的问题,结合南方水稻直播施肥的农艺要求,该研究设计了一种水稻直播机气流式施肥监测系统,可以在施肥装置出现管道堵塞后进行报警提示。首先,对气流式施肥监测系统的整体结构进行设计。然后,对关键部件气流分流管道建立仿真模型,采用Fluent和Rocky软件进行气固耦合仿真试验,以肥料颗粒的动能变化量为指标,对气流分流管道的防堵性能进行试验,仿真试验结果表明,当气流分流管道进气口施加800 Pa气流时,肥料颗粒的动能提高了39.7%。最后,采用Box-Behnken响应面试验设计方法进行台架静态试验,以堵塞报警准确率为评价指标,得出较优工作参数为气流分流管道内径28 mm,进气口气压值700 Pa,施肥速率20 g/s;以较优参数进行田间试验,结果表明,堵塞报警准确率均大于90.0%,最高达96.7%;装置工作稳定性好,未出现装置失灵情况,可满足水稻施肥装置堵塞监测准确率要求。该研究可为水稻施肥堵塞报警监测提供参考。

       

      Abstract: Rice fertilizer application is often disturbed by the moisture or mud and water in the field, particularly, in the rainy and humid southern region of China. The complicated working environment can result in fertilizer clogging or leakage in the fertilizer application machinery. The photoelectric and capacitive sensors are often developed to monitor the fertilizer application blockage at present. However, the traditional sensors are susceptible to fertilizer dust during operation, resulting in reduced sensitivity and even monitoring failure, which cannot meet the actual production needs. In this study, an airflow anti-clogging and monitoring system was proposed for fertilizer application in the rice direct seeding machine. The agronomic requirements were combined with the fertilizer application in the direct seeding of southern rice. The smoothness of the fertilizer application pipeline was effectively improved to prevent fertilizer clogging. Once the fertilizer clogging occurred, the alarm alerts were run in the system simultaneously. Firstly, the working principle of the fertilizer application system was determined to design the key components, such as the airflow diversion duct and the airflow change feedback device. At the same time, the structural parameters were optimized for the key components of devices. A parameter calibration test was carried out to determine the air pressure value (P1) of less than 1 000 Pa at the inlet of the airflow diversion duct. Secondly, a coupled simulation was carried out using Fluent and Rocky software. An experiment was then conducted to calculate the motion state of fertilizer particles with or without applied airflow in the airflow diversion duct of the key component. The test results showed that the velocity of fertilizer granules increased significantly under the action of airflow. The kinetic energy of the fertilizer granules increased by about 39.7%, compared with no airflow. It infers that the airflow effectively improved the smoothness of the fertilizer application pipeline. Finally, the prototype test was performed on the blockage monitoring and alarm performance of the device. The air pressure pre-test demonstrated that the air pressure of the air inlet should be taken as 600-800 Pa in the static test of the prototype. A combination of inlet air pressure, pipe inner diameter, and device fertilization rate was then tested to determine the optimal operating parameters of the device. The test protocol was designed by the Box-Behnken response surface method. After that, the regression model and the variation of the response surface were used to determine the inner diameter of the airflow diversion pipe of 28 mm, the air pressure value of 700 Pa at the air inlet, and the fertilizer application rate of 20 g/s, as the better working parameters of the device. The optimal combination of parameters was selected for the test in the field trials. Consequently, the accuracy of alarm monitoring was above 90.0%, and the highest accuracy was 96.7%. The better performance of the device was achieved in the stability, which fully met the requirement of clogging monitoring accuracy of the rice fertilizer device. The finding can provide an important reference for fertilizer application in the anti-blocking and blockage monitoring for rice production.

       

    /

    返回文章
    返回