宁静红,宋志朋,任子亮,等. 干冰喷雾速冻蓝莓的多孔阵列喷嘴[J]. 农业工程学报,2023,39(15):284-292. DOI: 10.11975/j.issn.1002-6819.202305053
    引用本文: 宁静红,宋志朋,任子亮,等. 干冰喷雾速冻蓝莓的多孔阵列喷嘴[J]. 农业工程学报,2023,39(15):284-292. DOI: 10.11975/j.issn.1002-6819.202305053
    NING Jinghong, SONG Zhipeng, REN Ziliang, et al. Porous array nozzle of dry ice spray quick-freezing blueberry[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2023, 39(15): 284-292. DOI: 10.11975/j.issn.1002-6819.202305053
    Citation: NING Jinghong, SONG Zhipeng, REN Ziliang, et al. Porous array nozzle of dry ice spray quick-freezing blueberry[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2023, 39(15): 284-292. DOI: 10.11975/j.issn.1002-6819.202305053

    干冰喷雾速冻蓝莓的多孔阵列喷嘴

    Porous array nozzle of dry ice spray quick-freezing blueberry

    • 摘要: 为提高速冻蓝莓的品质,该研究设计多出口阵列喷嘴干冰微粒喷雾速冻蓝莓系统,试验测试获得了蓝莓冻结过程中热物性参数随温度的变化规律,建立速冻腔体内干冰喷雾的速冻模型,利用Fluent软件对蓝莓速冻过程进行数值模拟仿真,获取优化入口流速和喷嘴出口孔径。结果表明:采用圆孔形收缩型喷嘴,设置喷射高度为120 mm,喷嘴入口孔径为30 mm,入口速度为0.25 m/s,出口为圆周孔径5.2 mm×6(6个孔径为5.2 mm的出口)和中心孔径2 mm×4的组合时,整盘蓝莓中心温度从1 ℃降至−18℃用时129 s,实现了蓝莓更均匀快速冻结。对模拟仿真优化结果进行试验测试,得到降温速率最慢的蓝莓完成速冻的时间为127 s,通过最大冰晶生成带的时间为36 s。试验与模拟降温曲线吻合良好。理化性质测试获得干冰微粒喷雾蓝莓速冻前后相关品质变化均优于速冻蓝莓标准。且与−80 ℃液氮喷淋速冻蓝莓的品质做对比,二者理化性质测试结果几乎无差异。研究结果可为进一步优化干冰喷射速冻蓝莓装置提供参考。

       

      Abstract: More cost-saving and efficient freezing is required to enhance the performance of quick freezing for blueberries. In this study, a new system was proposed to utilize a multi-outlet array nozzle for spraying blueberries with dry ice particles. Experimental tests were conducted to investigate the variations in the thermal properties of blueberries with temperature during the freezing process. These parameters were then input into Fluent software. A quick-freezing model was established for the dry ice particle spray inside the chamber. Numerical simulation was conducted to simulate the blueberry quick freezing using Fluent software. The optimal inlet flow velocity was successfully obtained to optimize the nozzle outlet diameter after the simulation. The results indicate that the better precooling of blueberries in cold water was to a temperature of 1 ℃. The nozzle was designed with six outlets in a circular array, where the central lines of the outlets were inclined at a 60° angle from the central line of the nozzle inlet, while the aperture size was 5.2 mm, and the nozzle was designed in a circular aperture shape with a contraction form. Additionally, four outlets were arranged at the center position of the nozzle's entrance axis, each with a diameter of 2 mm. The nozzle was configured with a spraying height of 120 mm, an entrance aperture measuring 30 mm, and an inlet velocity of 0.25 m/s. The center temperature of all the blueberries decreased from 1 ℃ to −18 ℃ in a total of 129 s, indicating the more uniform and quick freezing of the blueberries. Experimental testing was conducted to validate the simulation. An optimal combination was achieved in the freezing process of 127 s at the slowest cooling rate, with a time of 36 s for the formation of the maximum ice crystal generation zone. The cooling curves of the experimental process and the simulation process match well. The thawed blueberries were then subjected to physicochemical property testing after three days of storage. The results show that the blueberries subjected to quick freezing using dry ice particle spraying exhibited superior changes in their quality before and after freezing, compared with the CXS 103-1981 standard for frozen blueberries. A comparative experiment show that the blueberries were subsequently subjected to quick freezing using direct spraying of liquid nitrogen at −80 ℃. However, the dry ice cost much less for the quick freezing of blueberries, compared with the direct spraying with −80 ℃ liquid nitrogen. This low cost further enhanced the feasibility and economic viability of dry ice for blueberry freezing. The physicochemical property tests showed that there was almost no difference with the dry ice. The research findings can provide a solid foundation for the widespread application of the quick freezing of blueberries using dry ice spray.

       

    /

    返回文章
    返回