热泵间歇干燥白菜种子内部含水率变化规律

    赵海波, 杨 昭

    赵海波, 杨 昭. 热泵间歇干燥白菜种子内部含水率变化规律[J]. 农业工程学报, 2012, 28(11): 261-267.
    引用本文: 赵海波, 杨 昭. 热泵间歇干燥白菜种子内部含水率变化规律[J]. 农业工程学报, 2012, 28(11): 261-267.
    Zhao Haibo, Yang Zhao. Variation of moisture content in cabbage seeds with heat pump intermittent drying[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2012, 28(11): 261-267.
    Citation: Zhao Haibo, Yang Zhao. Variation of moisture content in cabbage seeds with heat pump intermittent drying[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2012, 28(11): 261-267.

    热泵间歇干燥白菜种子内部含水率变化规律

    基金项目: 国家自然科学基金资助项目(51076112),教育部博士点基金(200800560041),山东省高等学校科技计划(J12LB55)。

    Variation of moisture content in cabbage seeds with heat pump intermittent drying

    • 摘要: 为了研究热泵干燥条件下种子内部传质机理,以热泵干燥的白菜种子为研究对象,建立了其非均质动态传质模型,并利用该模型分析热泵恒温连续干燥与间歇干燥条件下种子内部含水率变化规律。研究表明,所建模型能较好的模拟种子含水率的动态变化,模拟值与试验值相关系数为0.9974,相对偏差在±10%以内,模拟精度满足要求;间歇干燥时种子内部含水率更均匀,更有利于种子品质的保证;间歇干燥过程比例系数取1/3、间歇运行周期中运行时间取400 s时热泵机组节能近50%。该研究可为热泵干燥技术的应用推广提供参考。
      Abstract: Aimed at studying the moisture diffusion mechanism inside the seeds during heat pump drying, a nonhomogeneous dynamic mass transfer model was set up for cabbage seeds analyze the moisture diffusion in the cabbage seed under conditions of continuous drying with constant temperature and intermittent drying with on/off pulsating of air velocity. Results showed that the simulation results coincided well with experimental data with correlation coefficient of 0.9974 and relative deviation being less than ±10%. With the heat pump intermittent drying, the moisture distribution inside the cabbage seed was more uniform. With intermittency ratio of 1/3 and on-time in the intermittent drying cycle of 400 s, nearly 50% energy conservation for the heat pump equipment could be achieved during the drying process. This research can provide a reference for application of heat pump drying technique.
    • [1] 陈东,谢继红. 热泵干燥装置[M]. 北京:化学工业出版社,2007.
      [2] 杨先亮,谢英柏,靳光亚. 热泵干燥婆枣的方案对比和试验对比[J]. 农业工程学报,2009,25(9):329-332.Xianliang, Xie Yingbai, Jin Guangya. Improved scheme and test comparison of drying jujube date using heat pump[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2009, 25(9): 329-332. (in Chinese with English abstract)
      [3] 蒋小强,关志强,谢晶. 水产品热泵干燥装置性能参数的理论分析[J]. 农业工程学报,2011,27(13):373-376.Jiang Xiaoqiang, Guan Zhiqiang, Xie Jing. Analysis on performance parameters of heat pump drying system[J] Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2011, 27(13): 373-376. (in Chinese with English abstract).
      [4] 向飞,王立,岳献芳. 半封闭热泵干燥系统的热力学分析与试验[J]. 农业工程学报,2009,25(2):240-245.Xiang Fei, Wang Li, Yue Xianfang. Thermodynamic analysis and experimental study of a semi-closed heat pump drying system[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2009, 25(2): 240-245. (in Chinese with English abstract).
      [5] 倪超,李娟玲,丁为民,等. 全封闭热泵干燥装置监控系统的设计与试验[J]. 农业工程学报,2010,26(10):134-139.Ni Chao, Li Juanling, Ding Weimin, et al. Design and experiment of monitoring system for heat pump dryer of enclosed cycles[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2010, 26(10): 134-139. (in Chinese with English abstract).
      [6] John S. Roberts, David R. Kidd, Olga Padilla-Zakour. Drying kinetics of grape seeds[J]. Journal of Food Engineering, 2008, 89(4): 460-465.
      [7] Velic D, Plantinic M, Tomas S, et al. Influence of airflow velocity on kinetics of convection apple drying[J]. Journalof Food Engineering, 2004, 64(1): 97-102.
      [8] 袁月明,陈丽梅,王鸿斌,等. 玉米丸粒化种子的薄层干燥试验及其干燥模型[J]. 农业工程学报,2003,19(3):169-173.Yuan Mingyue, Chen Limei, Wang Hongbin, et al. Experiment on thin layer drying of pelleted corn seed and its drying models[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2003, 19(3): 169-173. (in Chinese with English abstract).
      [9] 杨俊红. 植物性含湿多孔介质在干燥过程中优化传热传质机理的研究[D]. 天津:天津大学,1998.Yang Junhong. Study on the Mechanism of Optimizing Heat and Mass Transfer in Drying Process of Biological wet Porus Materials[D]. Tianjin: Tianjin University, 1998. (in Chinese with English abstract)
      [10] 杨俊红,楮治德,吕灿仁,等. 菜豆种子薄层干燥的潜力分析[J]. 干燥技术与设备,2008,6(1):19-23.Yang Junhong, Chu Zhide, Lv Canren, et al. Analysis of drying potential for thin layer drying of vegetable seed[J]. Drying technology and equipment, 2008, 6(1): 19-23. (in Chinese with English abstract)
      [11] 张嘉辉. 热泵干燥理论和种子干燥性能的研究[D]. 天津:天津大学,1999.Zhang Jiahui. The Study on Heat Pump Drying Theory and Properties of Seed Drying Process[D]. Tianjin: Tianjin University, 1999. (in Chinese with English abstract)
      [12] 李思远. 种子热泵干燥过程中传热传质以及生命物质变化规律研究[D]. 天津:天津大学,2007.Li Siyuan. Study on the Mechanism of Heat and Mass Transfer and Vitality Variation During Seed Heat Pump Drying Process[D]. Tianjin: Tianjin University, 2007. (in Chinese with English abstract)
      [13] Chua K J, Mujumdar A S, Chou S K. Intermittent drying of bioproducts-an overview[J]. Bioresource Technology, 2003, 90(3): 285-295.
      [14] 杨昭,王娟,李思远. 白菜种子热泵变温最佳干燥过程[J].天津大学学报,2008,41(6):673-677.Yang Zhao, Wang Juan, Li Siyuan. Temperature-variable optimal drying process of heat pump for cabbage seeds[J]. Journal of Tianjin University, 2008, 41(6): 673-677. (in Chinese with English abstract).
      [15] 杨世铭,陶文铨. 传热学[M]. 北京:高等教育出版社,2010.
      [16] Incropera F P, Dewitt D P, Bergman T L, et al. Fundamentals of heat and mass transfer(in Chinese translarion)[M]. 北京:化学工业出版社,2007.
      [17] 王正中,芦琴,郭利霞,等. 基于昼夜温度变化的混凝土衬砌渠道冻胀有限元分析[J]. 农业工程学报,2009,25(7):1-7.Wang Zhengzhong, Lu Qing, Guo Lixia, et al. Finite element analysis of the concrete lining channel frost heaving based on the changing temeprature of the whole body[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2009, 25(7): 1-7. (in Chinese with English abstract)
      [18] 孟春玲. 有限元法及ANSYS程序应用基础[M]. 北京:科学出版社,2008.
      [19] 盛骤,谢式千,潘承毅.概率论与数理统计[M].北京:高等教育出版社,2008.
      [20] 李雪峰,李卫军. 灌溉对苜蓿种子产量及其构成因子的影响[J]. 新疆农业科学,2006,43(1):21-24.Li Xuefeng, Li Weijun. Effect of irrigation on the yield and components of alfalfa seeds[J]. Xinjiang Agricultural sciences, 2006, 43(1): 21-24.
      [21] Chou S K, Chua K J, Hawlader M N A, et al. On the intermittent drying of an agricultural product[J]. Transactions of the Institution of Chemical Engineers, 2000, 78(4): 193-203.
      [22] 饶宾期,曹黎. 太阳能热泵污泥干燥技术[J]. 农业工程学报,2012,28(5):184-188.Rao Binqi, Cao Li. Technical research on sludge drying by solar energy and heat pump[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2012, 28(5): 184-188. (in Chinese with English abstract).
      [23] 张国琛,Sigurjón Arason,Sveinn Víkingur árnason. 热泵干燥北极虾的物理和感观特性研究[J]. 农业工程学报,2008,24(5).Zhang Guochen, Sigurjón Arason, Sveinn Víkingur árnason. Physical and sensory properties of heat pump dried shrimp (Pandalus borealis)[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2008, 24(5).(in Chinese with English abstract)
      [24] 张宏飞,张联英. 热泵干燥技术研究现状及发展趋势[J].干燥技术与设备,2009,7(3):120-124.Zhang Hongfei, Zhang Lianying. Research and development of heat pump drying technology[J]. Drying Technology and Equipment, 2009, 7(3): 120-124. (in Chinese with English abstract)
      [25] 张绪坤,李华栋,徐刚,等. 热泵干燥系统性能试验研究[J]. 农业工程学报,2006(4):94-98.Zhang Xukun, Li Huadong, Xu Gang, et al. Experimental study on the performance of heat pump drying system[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2006(4): 94-98. (in Chinese with English abstract)
      [26] 张璧光,高建民,伊松林,等. 我国木材干燥节能减排技术研究现状[J]. 华北电力大学学报,2009,36(3):38-43.Zhang Biguang, Gao Jianmin, Yi Songlin, et al. The present research situation of solar heat pump and heat pipe technology on lumber drying in China[J]. Journal of North China Electric Power University, 2009, 36(3): 38-43. (in Chinese with English abstract)
      [27] 张绪坤,李华栋,徐刚,等. 脱水蔬菜热泵-热风组合干燥试验[J]. 农业工程学报,2008,24(12):226-229.Zhang Xukun, Li Huadong, Xu Gang, et al. Combined heat-pump and hot-air drying of dehydrated vegetables[J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2008, 24(12): 226-229. (in Chinese with English abstract)
      [28] 石启龙,赵亚,李兆杰,等. 竹荚鱼热泵干燥数学模型研究[J]. 农业机械学报,2009,40(5):110-114.Shi Qilong, Zhao Ya, Li Zhaojie, et al. Mathematical modelling on heat pump drying of horse mackerel[J]. Transaction of the Chinese society for agricultural machinery, 2009, 40(5): 110-114.
      [29] 向飞,王立,岳献芳. 半封闭热泵干燥系统的热力学分析与试验[J]. 农业工程学报,2009,25(2):240-245.Xiang Fei, Wang Li, Yue Xianfang. Thermodynamic analysis and experimental study of a semi-closed heat pump drying system [J]. Transactions of the Chinese Society of Agricultural Engineering (Transactions of the CSAE), 2009, 25(2): 240-245. (in Chinese with English abstract)
      [30] 史伟勤,楼唯,张金妹,等. 采用新型环保型制冷剂的新型真空冷冻干燥机的研发[J]. 干燥技术与设备,2008,6(5):225-228.Shi Weiqin, Lou Wei, Zhang Jinmei. R&D of the new vaccum freeze dryer using environment-friendly refrigerant[J]. Drying technology & equipment, 2008, 6(5): 225-228. (in Chinese with English abstract).Variation of moisture content in cabbage seeds with heat pump intermittent drying
    计量
    • 文章访问数:  1359
    • HTML全文浏览量:  0
    • PDF下载量:  685
    • 被引次数: 0
    出版历程
    • 收稿日期:  2011-10-19
    • 修回日期:  2012-04-26
    • 发布日期:  2012-05-31

    目录

      /

      返回文章
      返回