适宜猪粪与菌渣配比提高堆肥效率

周江明; 王利通; 徐庆华; 姜新有

doi:10.3969/j.issn.1002-6819.2015.07.029

适宜猪粪与菌渣配比提高堆肥效率

1.
江山市农业技术推广中心，江山 324100
2.
浙江天蓬畜业有限公司，江山 324111

基金项目: 江山市科技项目（2014C16）

计量
- 文章访问数: 3552
- HTML全文浏览量: 2
- PDF下载量: 1128
出版历程
- 收稿日期: 2015-02-10
- 修回日期: 2015-03-14
- 发布日期: 2015-03-31

Optimum ratio of pig manure to edible fungi residue improving quality of organic fertilizer by composting

1.
The Agricultural Technique Popularization Centre of Jiangshan City, Jiangshan 324100, China
2.
Zhejiang TianPeng Animal Husbandry Ltd, Jiangshan 324111, China

摘要

摘要: 为摸索猪粪和菌渣堆肥生产有机肥技术，在自然发酵条件下，设计猪粪和菌渣9:1、8:2、7:3、6:4 4种不同比例（湿质量比）进行高温堆肥试验，研究了堆肥过程中温度、pH值、有机碳、发芽指数及养分氮、磷、钾的动态变化。结果表明，堆体温度在第3天即达50℃以上，保持高温25～32 d后开始下降，其中6:4处理高温期比9:1处理长7 d；4个处理pH值都呈先快速上升、之后下降并趋于稳定的趋势，pH值在6.83～8.62间变化；有机碳(质量分数)总体上呈下降之势，至堆肥结束4个处理分别下降了16.3%、14.5%、13.6%和11.9%，菌渣比例提高可减少堆体有机碳的损失；除6:4处理外，其他处理发芽指数分别于23、33和47 d达80%以上，同一时期菌渣比例越高堆体提取液对植物的毒害作用越强；氮磷钾总养分（质量分数）前期（约19 d）呈基本持平或少量下降，随后持续上升，堆肥结束4个处理分别为5.93%、5.57%、5.64%和5.13%。6:4处理氮磷钾总养分在堆肥大部分时期（45 d内）≤5.0%，其他处理在21～25 d后均≥5.0%。综合考虑堆肥质量和堆期等因素，利用猪粪和菌渣为原料规模化生产机肥，猪粪和菌渣适宜的比例为8:2。同时，因猪粪和菌渣C/N均较低，建议适当增加米糠等C/N高的添加料，进一步提高堆肥效率。
- 堆肥 /
- 粪 /
- 农业废弃物 /
- 菌渣 /
- 有机肥
Abstract: Abstract: In order to solve the current problems about environmental pollution of agricultural waste and explore the technology of producing organic fertilizer by composting with pig manure and edible fungi residue, an experiment was conducted to study dynamic changes of several parameters including heat, pH value, organic carbon (C), germination index (GI), nutrient nitrogen (N), phosphorus (P) and potassium (K) during the natural fermentation. The experiment was based on the four ratios of 9:1, 8:2, 7:3 and 6:4 of pig manure and edible fungi residue in high-temperature composting experiment. The results showed as followed. The temperatures of all disposals were over 50 degrees centigrade at about the 3rd day. It maintained a high temperature for from 25 to 32 d, and then began to decrease. Duration of the high-temperature composting was longer while the ratio of the mushroom residue got more. From the experiment, we could see that the high-temperature duration of the disposal with the ratio of 6:4 was 7 d longer than the disposal with the ratio of 9:1. The pH values of all disposals, ranging from 6.83 to 8.62, increased rapidly and then decreased smoothly in the 22 d. Total N of the nutrient decreased with the loss of ammonia in the early, and then the relative quality of the total N began to rise while the total mass was reducing along with the loss of C content. At the end of the composting, the total N contents of the disposals A and B decreased by 2.9 and 1.0 g/kg, respectively, but the disposals C and D increased by 1.6 and 1.9 g/kg, respectively. The total P and total K contents have been on a slow upward trend, until the end of the composting they increased by 14.2%-36.4% and 28.1%-34.7% respectively. The organic C content decreased in general. At the end of the composting, the organic C contents of all disposals respectively decreased by 16.3%, 14.5%, 13.6% and 11.9%. Due to the rich source of N in the early time, microbes multiplied and let out large-scale ammonia N, which resulted in the rapid increase in the C/N ratio, and then the average ratio declined; and the 4 disposals decreased by 0.67, 2.08, 4.48 and 4.49 respectively in the end. Except the disposal with the ratio of 6:4, the GI of all disposals respectively reached 80% on the 23rd, 33rd, 47th day. At the same time, the toxicity of the piles extract liquid increased on plants due to the accretion of the ratio of fungi residue. The total nutrient contents of N, P and K were in a flat or a small decline and then continued to rise in the early period (in about 19 d), which were respectively 5.93%, 5.57%, 5.64% and 5.13% for all disposals at the end of the composting. In addition, the disposal with the ratio of 6:4 was less than 5% in the most period of the composting (within 45 d), but the rest disposals were more than 5% after about 21-25 d. Considering the factors of the compost quality and production cycle comprehensively, the appropriate ratio of manure to mushroom residue is 8:2 for making scale production of organic fertilizer. Furthermore, on account of the low C/N ratio of manure and mushroom residue, it is better to add some annexing agent with high C/N ratio such as rice bran for improving the efficiency of composting.
- composting /
- manures /
- agricultural wastes /
- edible fungi residue /
- organic fertilizer

HTML全文

参考文献(42)

[1]	杨帆，李荣，崔勇，等. 我国有机肥料资源利用现状与发展建议[J]. 中国土壤与肥料，2010(4)：77－82.Tang Fan, Li Rong, Cui Yong, et al. Utilization and develop strategy of organic fertilizer resources in China[J]. Soil and Fertilizer Sciences in China, 2010(4): 77－82. (in Chinese with English abstract)
[2]	卫智涛，周国英，胡清秀. 食用菌菌渣利用研究现状[J].中国食用菌，2010，29(5)：3－6，11.Wei Zhitao, Zhou Guoying, Hu Qingxiu. Research and utilization of edible fungi residue[J]. Edible Fungi of China, 2010, 29(5): 3－6, 11. (in Chinese with English abstract)
[3]	黄鸿翔，李书田，李向林，等. 我国有机肥的现状与发展前景分析[J]. 土壤肥料，2006，14(1)：3－8.Huang Hongxiang, Li Shutian, Li Xianglin. Analysis on the status of organic fertilizer and its development strategies in China[J]. Soil and Fertilizers, 2006, 14(1): 3－8. (in Chinese with English abstract)
[4]	Michael A Mallin, Lawrence B Cahoon. Industrialized animal production: A major source of nutrient and microbial pollution to aquatic ecosystems[J]. Population and Environment, 2003, 24(5): 369－385.
[5]	刘东，马林，王方浩，等. 中国猪粪尿N产生产生量及其分布的研究[J]. 农业环境科学学报，2007，26(4)：1591－1595.Liu Dong, Ma Lin, Wang Fanghao, et al. Research on quantity and distribution of China pig manure N[J]. Journal of Agro-Environment Science, 2007, 26(4): 1591－1595. (in Chinese with English abstract)
[6]	Carpenter S R. Phosphorus control is critical to mitigating eutrophication[C]// Proceedings of the National Academay of Sciences of the Unitied States of America, 2008, 105(32): 11039－11040.
[7]	Paer W H, Huisman J. Blooms liks it hot[J]. Science, 2008, 320(4): 57－58.
[8]	Wang Haijun, Liang Xiaoming, Jiang Pinghong, et al. TN: TP ratio and planktivorous fish do not affect nutrient-chlorophyll relationships in shallow lakes[J]. Freshwater Biology, 2008, 53(5): 935－944.
[9]	石嫣，程存旺，朱艺，等. 中国农业源污染防治的制度创新与组织创新--兼析《第一次全国污染源普查公报》[J]. 渔业经济研究，2011(2)：27－37.Shi Yan, Cheng Chunwang, Zhu Yi, et al. Institutional and organizational innovation on China agricultural non-point pollution prevention: Analysis on thd 1st national survey of pollution sources bulletin[J]. Agricultural Economics and Management, 2011(2): 27－37. (in Chinese with English abstract)
[10]	Mishima S I, Kimura S D, Eguchi S, et al. Estimation of the amounts of livestock manure, rice straw, and rice straw compost applied to crops in Japan: A bottom-up analysis based on national survey data and comparison with the results from a top-down approach[J]. Soil Science and Plant Nutrition, 2012, 58(1): 83－90.
[11]	黄红英，常志州，叶小梅，等. 区域畜禽粪便产生量估算及其农田承载预警分析--以江苏为例[J]. 江苏农业学报2013，29(4)：777－783.Huang Hongying, Chang Zhizhou, Ye Xiaomei, et al. Estimation of regional livestock manure production and farmland loading capacity: A case study of Jiangsu province[J]. Jiangsu J of Agr Sci, 2013, 29(4): 777－783. (in Chinese with English abstract)
[12]	Zervas G, Tsiplakou E. An assessment of GHG emissions from small ruminants in comparison with GHG emissions from large ruminants and monogastric livestock[J]. Atmospheric Environment, 2012, 49: 13－23.
[13]	胡涛，王加启，卜登攀，等. 畜禽粪尿氮污染情况及降低污染的措施[J]. 中国畜牧兽医，2010，37(2)：207－210.Hu Tao, Wang Jiaqi, Bu Dengpan, et al. The livestock's fecal and urinary nitrogen pollution and the measures of reducing the pollution[J]. Chinese Animal Husbandry and Veterinary Medicine, 2010, 37(2): 207－210. (in Chinese with English abstract)
[14]	Berg W, Brunsch R, Pazsiczki I. Greenhouse gas emissions from covered slurry compared with uncovered during storage[J]. Agriculture, Ecosystems and Environment, 2006, 112(2/3): 129－134.
[15]	Arthur R, Baidoo M F. Harnessing methane generated from livestock manure in China, Nigeria, Mali and Burkina Faso[J]. Biomass & Bioenergy, 2011, 35(11): 4648－4656.
[16]	Bernal M P, Alburquerque J A, Moral R. Composting of animal manures and chemical criteria for compost maturity assessment[J]. Bioresource Technology, 2009, 100(22): 5444－5453.
[17]	朱建春，张增强，樊志民，等. 中国畜禽粪便的能源潜力与氮磷耕地负荷及总量控制[J]. 农业环境科学学报，2014，33(3)：435－445.Zhu Jianchun, Zhang Zengqiang, Fan Zhimin, et al. Biogas potential, cropland load and total amount control of animal manure in China[J]. Journal of Agro-Environment Science, 2013, 33(3): 435－445. (in Chinese with English abstract)
[18]	李书田，刘荣乐，陕红. 我国主要畜禽粪便养分含量及变化分析[J]. 农业环境科学学报，2009，28(1)：179－184.Li Shutian, Liu Rongle, Shan Hong. Nutrient contents in main animal manures in China[J]. Journal of Agro-Environment Science, 2009, 28(1): 179－184. (in Chinese with English abstract)
[19]	周文兵，刘大会，朱端卫. 不同调理剂对猪粪堆肥过程及其养分状况的影响[J]. 华中农业大学学报，2004，23(4)：421－425.Zhou Wenbing, Liu Dahui, Zhu Duanwei. The effect of different conditions on composting process of pig faces and their nutrients status[J]. Journal of Huazhong Agricultural University, 2004, 23(4): 421－425. (in Chinese with English abstract)
[20]	黄华，黄懿梅，刘学玲，等. 覆盖处理对猪粪秸秆堆肥中氮素转化和堆肥质量的影响[J]. 环境科学学报，2013，33(3)：780－786.Huang Hua, Huang Yimei, Liu Xueling, et al. Effect of covering on nitrogen transformation and the quality of pig manurestraw compost[J]. Acta Scientiae Circumstantiae, 2013, 33(3): 780－786. (in Chinese with English abstract)
[21]	万水霞，朱宏赋，李帆，等. 食用菌菌渣的综合利用研究[J]. 园艺与种苗，2011(6)：12－14，89.Wan Shuixia, Zhu Hongfu, Li Fang, et al. Study on comprehensive utilization of edible fungi residue[J]. Horticulture & Seed, 2011(6): 12－14, 89. (in Chinese with English abstract)
[22]	Mata A J, Macé S, Llabrés P. Anaerobic digestion of organic solid wastes: An overview of research achievements and perspectives[J]. Bioresource Technology, 2000, 74(1): 3－16.
[23]	Wilkinson K G. A comparison of the drivers influencing adoption of on-farm anaerobic digestion in Germany and Australia[J]. Biomass and Bioenergy, 2011, 35(5): 1613－1622.
[24]	翁俊基. 过磷酸钙在猪粪堆肥过程中的保氮效果研究[J].安徽农业科学，2012，40(8)：4528－4529，4617.Weng Junji. Nitrogen conservation of calcium superphosphate in swine manure compost[J]. Journal of Anhui Agricultural Sciences, 2012, 40(8): 4528－4529, 4617. (in Chinese with English abstract)
[25]	程绍明，马杨珲，姜雄晖. 不同木屑含量对猪粪好氧堆肥过程的影响研究[J]. 江西农业大学学报，2009，31(5)：833－836.Cheng Shaoming, Ma Yanghui, Jiang Xionghui. The effects of different wood contents on composting process of pig Manure[J]. Acta Agriculturae Universitatis Jiangxiensis, 2009, 31(5): 833－836. (in Chinese with English abstract)
[26]	王卫平，朱凤香，陈晓旸，等. 添加砻糠对猪粪堆肥发酵层温度及氮素变化的影响[J]. 浙江农业学报，2009，21(6)：579－582.Wang Weiping, Zhu Fengxiang, Chen Xiaoyang, et al. Effect of rice chaff with different additional amount on the changes of nitrogen and temperature in pig manure composting[J]. Acta Agriculturae Zhejiangensis, 2009, 21(6): 579－582. (in Chinese with English abstract)
[27]	柴晓利，张华，赵由才. 固体废物堆肥原理与技术[M]. 北京：化学工业出版社，2005：83－84.
[28]	MacGregor S T, Miller F C, Psarianos K M, et al. Composing process control based on interaction between microbial heat output and temperature[J]. Applied and Environmental Microbiology, 1981, 41(6): 1321－1330.
[29]	Wiley J S, Pierce G W. A preliminary study of high rate composting[J]. Transactions of the American Society of Civil Engineers, 1957, 122(1): 1009－1030.
[30]	秦莉，沈玉君，李国学，等. 不同C/N比对堆肥腐熟度和含氮气体排放变化的影响[J]. 农业环境科学学报，2009，28(12)：2668－2673.Qin Li, Shen Yujun, Li Guoxue, et al. The impact of composting with different C/N on maturity variation and emission of gas concluding N[J]. Journal of Agro-Environment Science, 2009, 28(12): 2668－2673. (in Chinese with English abstract)
[31]	Jimenez E I, Carcia V P. Composting of domestic refuse and sewage sludge: I. Evolution of temperature, pH, C/N ratio and cationexchange capacity[J]. Resource, Conservation and Recycling, 1991, 6: 45－46.
[32]	Nakasaki K, Yaguchi H, Sanaki Y, et al. Effect of pH control on composting of Garbage[J]. Waste Management and Research, 1993, 11(2): 117－125.
[33]	Sharma V K, Canditilli M. Processing of urban and agro-industrial residues by aerobic composting: Review[J]. Energy Covers Management, 1997, 38(5): 452－478.
[34]	Emeterio I J. Evaluation of city refuse compost maturity: A review[J]. Biological Wastes, 1989, 27: 115－141.
[35]	单德鑫，李淑芹，许景钢. 好氧堆肥对难溶性磷转化的影响[J]. 环境科学学报，2009(1)：146－150.Shan Dexin, Li Shuqin, Xu Jinggang. Effects of aerobic composting on transformation of rock phosphate[J]. Acta Scientiae Circumstantiae, 2009, 29(1): 146－150. (in Chinese with English abstract)
[36]	Hellmann B, Zelles L, Palojarvi A, et al. Emission of climate-relevant trace gases and succession of microbial communities during open-window composting[J]. Applied and Environmental Microbiology,1997, 63(3): 1011－1018.
[37]	Morel T L, Colin F, Germon J C, et al. Methods for the evaluation of the maturity of municipal refuse compost[C]// Composting of agriculture and other wastes Ed J, London and New York: R Gasser. Elsevier Applied Science Publishers, 1985: 74－78.
[38]	Garcia C, Hernaandez T, Fosta, et al. Evaluation of the maturity of municipal waste compost using simple chemical[J]. Commun Soil Sci Plant Annal, 1992, 23:1501-1512.
[39]	Zucconi. Evaluating toxicity of immature compos[J]. Biocycle, 1981, 22: 54－57.
[40]	Zucconi. Biological evaluation of compost maturity[J]. Biocycle, 1981, 22: 27－29.
[41]	Riffaldi R, Levi-Minzi R, Pera A, et al. Evaluation of compost maturity by means of chemical and microbial analyses[J]. Waste Management and Research, 1986, 4: 387－396.
[42]	Mathur S P. Determination of compost biomaturity. I. Literature review[J]. Biological Agriculture and Horticulture, 1993, 10: 650－685.

施引文献

资源附件(0)

计量

文章访问数: 3552
HTML全文浏览量: 2
PDF下载量: 1128
被引次数: 0

适宜猪粪与菌渣配比提高堆肥效率

计量

出版历程

Optimum ratio of pig manure to edible fungi residue improving quality of organic fertilizer by composting

计量

出版历程

目录